Volkswagen Polo Service & Repair Manual: Extraction System Group Classifications
| At this time, A/C service units for extracting, cleaning and
filling refrigerant for motor vehicle A/C systems are available
from various manufacturers. |
| Mobile extraction and charging systems for filling
compressed-gas vessels permanently connected to the system. |
| The refrigerant or refrigerant/oil mixture is transferred to
compressed gas vessels which are permanently connected to the
mobile systems. In accordance with 3 Para. 5 No. 3 of pressure
vessel regulations, compressed-gas vessels are classified as
pressure vessels in this case. |
| The charging systems require: |
| no expert testing as the gas is transferred to
compressed-gas vessels which are classed as being pressure
vessels. (Systems used for transfer from these pressure vessels
to compressed-gas vessels for supplying to third parties do
require a permit and are subject to mandatory testing). |
 Note
| The A/C service and recycling units used in motor vehicle
workshops are extraction and charging systems not requiring a
permit (Group “3”) but which are only to be operated by
qualified personnel. Instructions for unit operation and
maintenance can be found in the relevant manufacturer's
documentation. |
|
|
|
At this time, A/C service units for extracting, cleaning and
filling refrigerant for motor vehicle A/C systems are available
from various manufacturers.
...
Other materials:
Water Content
Only very small amounts of water are soluble in liquid
refrigerant. On the other hand, refrigerant vapor and water
vapor mix in any ratio.
Only a small drop of water may get into the refrigerant
circuit. The dryer, dryer bag or dryer car ...
Warning lamp
First read and observe the introductory information
and safety warnings
Lit up
Possible cause
Solution
The tailgate is open or not properly closed.
Do not drive on!
Open the tailgate and close it again.
Several warning and ...
Wear Spots
A wear spot is a flat spot on the tread of the tires that
can be caused by extreme braking maneuvers on subsurface such as
asphalt.
At the same time a tire during the braking maneuver is
rubbed at selective points which ...
© 2016-2026 Copyright www.vwpolo.net
Charging Systems not Requiring a Permit